2024年4月19日发(作者：)

服装

QC

英语/中文

1、Appearance 夕卜观

Dirty mark 污渍

Water spot水斑点

water stain 水渍

Cleaning mark枪水渍（打枪痕渍）

oil stain 油渍

rust锈迹

undesirable odor 臭味

There is dirty mark on garment 衣服上有脏迹

dirty dot （较小的）污点

dirty spot （较大的）污点

color fibre woven in 杂色纤维织入（面料上有杂色纱线）

color yarn 杂色纱

mix color yarn 杂色纱织入（面料中）

loom fly飞花织入

color thread end left inside , trapped color thread end 藏色线（撞色线头被车在

衣服封闭部位内）

broken yarn 断纱

thick yarn 粗纱

yarn drawn out 抽纱

knot结头

slub毛粒 looping 起耳仔

bubble起泡

pilling 起球

broken hole 破洞

off grain 丝缕歪（布纹歪）

streaky mark 起横

fabric defect 布疵

knit fault 织疵

major defect大疵，严重疵点（大鸡）

minor defect小疵，轻微疵点（细鸡

）

thread end 线头

yarn end 毛头

fly up飞起,翘起

right side 正面

wrong side 反面

wrong seam type 缝骨类型错

poor hand feel of product- not as specified 手感与确认样不符

X is 1"smaller than spec某部位比尺寸表小1英寸

X is T'above than spec某部位比尺寸表

大

1英寸

The proportion of 60% 比例达 60%

2、Stitching quality 缝制

stitching quality is not good 缝制不良

stitch seam is uneven

双轨接线

stitch seam leans out line 线路偏移

bad join stitching , poor repair stitching 接线不良（驳线不良）

overlap stitching 接线（驳线

）

poor back stitch 回针不良（返针差

）

poor linking 连接不良

broken stitch 断线

run off stitch （车缝）落坑

raw edge , raw-edge

散

口

open seam , seam opening 开缝，裂缝（爆口

seam slippage 线缝松脱（爆口

）

stitch not in seam shadow 露暗线

skipping stitch 跳线

skipping 跳针

drop needle漏针,抽针，抽条，抽窿

needle hole针洞，针孑L

seam overturn 缝头方向错（止口反骨）

pleated sewing 车缝打褶

pucker起皱

seam puckering线缝皱缩（骨位皱）

seam twist缝骨扭

seam wavy缝骨起波浪（缝骨起蛇

）

）

sewn in waste车缝时混有杂物

needle damage （缝针导致的）面料损坏

stitch density uneven 线迹密度不均匀

stitch tension uneven 线迹张力不均匀

3、Collar 领

Uneven collar 歪领

collar deviates from front center line 倘领偏斜

creases below neckline 领窝不平

bunches below back neckline 后领窝起涌

wrinkles at top collar 领面松

top collar appears tight 领面紧

crumples at top collar 领面起泡

collar band is longer than collar 底领伸出

collar band is shorter than collar 底领缩进

wrinkles at collar band facing内领座起皱（内下级领起皱

）

collar band lean out of collar 底领夕卜露

collar edge appears loose 领夕卜口松

collar edge appears tight 领夕卜 口 紧

collar points high/low 领尖高低，领尖不对称（不在同一水平■线）

overlap collar 叠领

tight neckline 领卡脖

collar stand away from neck 领离脖

wrinkles at top lapel 驳头起皱

top lapel appears tight 驳头反翘

lapel edge appears loose 驳头夕卜 口 松

lapel edge appears tight 驳头夕卜 口 紧

lapel roll line is uneven 驳 口不直

gorge line is uneven 申 口 不直

Broken collar / cuff and hem 烂镇

Looping at neckline 领圈起耳仔

4、 Shoulder 小肩

puckers at shoulders 小肩起皱

wrinkles at shoulder 塌肩

shoulder pucker 肩缝皱

5、 Armhole 袖隆

armhole pucker袖窿起皱，火圈起皱

puckers at underarm seam 袖隆缝起皱

diagonal wrinkles at sleeve cap 绡袖不圆顺

6、 Sleeve 袖子

sleeve leans to front 袖子偏前

sleeve leans to back 袖子偏后

inseam leans to front 前袖缝夕卜翻

diagonal wrinkles at sleeve lining 袖里拧

inner cuff visible/exposed 袖头止口反吐，袖头内层外露

wrinkles at sleeve opening 袖 口 起皱

cuff edge not level 袖 口 边不平齐

uneven length of sleeves 左右袖长不等，长短袖

7、Placket 门襟

grin露齿，裂口

wrinkles at zip fly 拉链起皱

zipper not movable 拉链难以开合

zipper wavy拉链起波浪，拉链起蛇

placket wavy前筒起蛇（皱）

neck drop pucker 门襟顶部起皱

placket bottom spread open 门襟豁（筒脚张开

）

facing leans out from front edge 前襟止 口反吐（里料夕卜露）

bump at placket edge 门襟边扣眼位凸起（筒边钮门位不顺直

）

placket wavy门襟起波浪（不平■伏）

creases at right fly 里襟里起皱

under placket exposed 里襟外露、底筒外露

uneven length of plackets 里夕卜襟长短

fabric too close to zipper 面布车得太贴近拉链

lining too full/tight 里布太多 /太紧

horizontal seams not level水平缝骨（左右）没对齐

hem not level下摆边不平齐

wrinkles at hem 底边起皱

8、 Pockets 口袋

slanting pocket 歪袋

uneven lips （袋口）嵌线宽不均匀（大小唇）

overlap lips 叠唇

pockets high/low （左右）口袋不对称（高低袋）

flap lining leans out of edge 袋盖反吐

flap edge is uneven 袋盖不直

pocket flap stick up 袋盖反翘

creases on two ends of pocket mouth 袋 口 角起皱

split at pocket mouth 袋口裂

smiling pocket 袋口豁，（口袋）笑口

underply exposed , underply turn out 止口 反吐，里层夕卜露

Rock / sand inside pockets 袋内有石

9、 Rides up 起吊

back of coat rides up 后身起吊

center back ride up , center back seam pulling 后中起吊

hiking up 起吊

hiking at bottom of placket 前筒吊脚

outseam/inseam pulling （侧缝 / 内缝）吊脚

split hem line rides up 裙身吊

10、

Pants

裤子

wrinkles at waistband facing 腰缝起皱

bunches below waistline seam 腰缝下 口 涌

support stitch visible辅助线外露，定位线外露

end of waistband is uneven 腰头探出

crotch cross unmatch 裤裆十字骨错位

wrinkles at front rise 前浪不平

slack seat 后裆下ft

tight crotch 夹裆

short seat 短裆

bursting of crotch seam 裆缝断线

twist leg扭髀扭脚

two legs are uneven 裤脚前后

leg opening is uneven 脚 口 不齐

11、

Skirt

裙子

split at lower part of skirt 裙桐豁开

skirt flare is uneven 裙浪不匀

12、 Vent 衩

lack of fullness at chest 塌胸

dart point crumple 省尖起泡，省尖起皱 back vent unmeet 背衩豁（张开） crossed back

vent背衩搅（重叠太多） crossing at back vent 背衩搭叠过多

13、 Printing 印花

printing scrimp 印花起裂

wrong color combo 颜色组合错误

wrong pattern 图案错误

uneven color深浅色，颜色不均匀

uneven dying 染色不均匀

color too dull/bright 颜色太哑 / 闪

total different color 颜色完全不同

color fading 褪色、甩色

stripy色挡，色花

marking off 搭色

color shade, off shade, color deviation 色差

color shading within one garment （同件衣服内） 裁片色差

shading garment to garment 衫与衫之间色差

embroidery design out line is uncovered 绣花不良

14、 Stripes 条格

stripes not match 对条不良

checks not match 对格不良

uneven plaids格仔不均匀

mismatched stripe/plaid,side seam1/8 ”-1/4 ”对格对条不佳，侧缝处偏差 1/8-1/4

15、 Front edge 止口

front edge is uneven 止 口 不直

front edge is out of square 止 口缩角

front edge is upturned 止 口 反翘

facing leans out of front edge 止 口 反吐

split at front edge 止口豁

crossing at front edge 止 口下部搭叠过多

16、 Puckers 行棉

puckers at quilting 乡亍棉起皱

padded cotton is uneven 絮棉不均

empty hem 边缘缺棉

17、Washing 洗水

Uneven washing effect

Different washing effect

洗水效果不均

洗水效果不同

washing quality is not good 洗水不良

washing streak 洗水痕

Streaky mark洗水条纹痕

Crease mark洗水摺痕

overwash 洗水过度，洗水太重

Pilly / hairy on garment surface

Sandy on garment surface

洗水后表面有毛粒或起毛

衣服表面有沙的感觉

Mildew or heavily odor garment. 霉味或很重的味在衣服上

18、Pressing 整烫

poor ironing 烫工不良

underpress 熨烫不够

overpress熨烫过度、烫过火

iron-shine 极光

Melt熔化

Glazing / shinny pressed 起^

Sheer / glossy 起IBS

glaze mark （熨烫）起镜，起极光

Crease mark 摺痕印

Burn mark燎焦印

pressing mark 烫痕，压痕

Pleated press 熨褶痕

seam gapping 藏木虱，藏止口（烫工）

Color stain IS色斑点

Wet 潮湿

crease line leans to outside 烫迹线外撇

crease line leans to inside 烫迹线内撇

Seam not fully pressed open 骨位没有完全熨开

Zip / button mark made by improper pressing 熨工欠佳致有拉链痕纽痕

Elastic is not pre-shrinkage before setting 橡筋未烫金宿水

Poor pressing / fusing of interlining

烫米寸压米寸效果不佳

19、Trims 辅料

Production status 生产情况

Missing price ticket / hangtag / label 欠价钱牌

Wrong placement of price ticket / hangtag / label 价钱牌、挂牌、唆头位置错误

Wrong size / color in assortment 尺而焉 SB色分配错误

Carton/casepack assortment incorrect 包装搭配不正确

wrong size indicated 错码

off size尺寸不合

Improper folding 摺法不正确

Dirty polybag 胶带污渍

Broken export carton 夕卜箱烂

Carton over weight 夕卜箱重

Incorrect carton size 夕卜箱尺寸不合猊格

20、AQL table抽检比例

shipment pcs

sampling size

FROM

26

51

91

151

281

501

1201

AQL 1.5

accept

50

90

8

13

20

32

50

80

125

0

0

0

1

2

3

5

reject

1

1

1

2

3

4

6

AQL 2.5

accept

0

0

1

2

3

5

7

reject

1

1

2

3

4

6

8

TO

150

280

500

1200

3200

3201

10001

10000

35000

200

315

7

10

8

11

10

14

11

15